Slab-on-grade Foundation

A concrete slab is poured into a mold directly into the ground. This slab serves directly as the floor for the main level of the home. This type of foundation is cheap to build, but should not be used in extremely cold climates, where the ground freezes for long periods of time. Slab-on-grade foundations can provide a good economical solution for relatively flat building lots in mild or moderate climates. If used in combination with radiant in floor heating the slab can be a beautiful and comfortable finished floor.

One problem with slab-on-grade and log homes is plumbing and electric: The subfloor of the main level of a house provides easy accessible space to run vents, plumbing pipes and electric cables. When using a slab-on-grade the plumbing and electric installation requires more planning, as everything needs to be laid out in advance, so that the pipes can be placed inside the concrete.

Crawl space

This is a non-insulated basement type where one cannot stand, mostly somewhere around 40 inches high. It keeps the house off the ground to protect it from moisture and insects, and offers convenient access to plumbing and electric installation. The bottom surface of the crawl space can either be soil or poured concrete. It can be used for some storage, but it’s not considered living space. A crawl space can be used to create a level building area on a sloped lot, and it keeps the house higher off the ground to provide better protection from weather and insects.

For our show home in Saanich I chose to build a full hight basement with ICF blocks. The Styrofoam blocks look like huge Lego for adults. The walls are built with these blocks, and window and door openings are framed into the walls. The blocks have plastic clips to hold rebar. At the end, concrete is poured into the space between the 2 styrofoam walls.

This method has many advantages:

• Saves time and labor cost, as no traditional wall framing is required
• Provides and excellent insulation. The ICF blocks I used resulted in a R28 insulated wall
• Saves time and labor for finishing the inside walls: Drywall can be drilled directly into the styrofoam, no additional framing required
• Reduced amount of garbage during basement construction

The material cost of an ICF basement is higher then building a “regular” concrete basement. But the time savings and better insulation will offset that.

Our building team took about 3 weeks with 2 people from building the footings until pouring the concrete for all ICF walls.

Building A Log Home – Part 2, Foundation / Basement is a post from: EcoLog-B-log

We wanted to know how a “log look” can improve some well known buildings. Several short video clips will show some interesting and most unusual “log buildings”, starting with Big Ben, the “grand daddy of all clock towers”.

Check out the videos on this page – new videos will be added over the next few weeks.

Your comments / ratings / feedback are welcomed !

Have a Laugh: New videos from EcoLog-Homes.com is a post from: EcoLog-B-log

Read the article above and join the discussion. I would love to hear from as many people as possible about their building process experience, as information about this is very thin on the the net.

Building a custom log home in BC is a post from: EcoLog-B-log

I started my lot search around Feb. 2009 in the Greater Victoria area. My realtor setup an automatic MLS search using my search criteria, and I got listings offered every week. I looked at some lots, but mainly to get an idea what I really wanted. And thankfully I didn’t come across my “dream property” at this time: I didn’t have financing approved yet, and wouldn’t have been able to buy at that time.

Getting Financing in 2009

I thought it couldn’t be too difficult to get financing for an interesting building project, with quite a bit of equity available for security. But I guess I was wrong with that. It turned out that no bank wanted to take any risk – no matter how small it was. I went from one institution to another and told my story: I’m starting a new business, have some good equity in my nearly mortgage free home, and want to build another home. Equite sounded good for the banks – but as soon as they heard that I had no regular income, but was building a new business, they shut their doors. I couldn’t even get 50% of the building lot as a mortgage. So much for the effect of the US housing crisis in Canada !

I finally found a very engaged lady at Bank of Montreal, who listened to my plans and believed that my ideas could work. She put a lot of effort into preparing my case, and presenting it to the bank’s risk managers. After several weeks she succeeded not only in getting a stepped mortgage plan approved, but even offering some really good rates. As part of the deal I moved all my financial business (daily banking, financing, mortgage for existing house) to BMO.

Getting Serious

On June 15th my financing was approved, and that’s when I started to look more seriously for building lots. I looked at many lots, from Sooke over Metchosin to Saanich, even around the Malahat and Shawnigan area. On July 2nd I found a “good fit” at a reasonable price through the http://propertyguys.com website. The lot was a subdivision of a bigger property, and was located in a good location in Central Saanich. It was a private sale, and my “house realtor” was on vacation. I got in touch with the seller on a Friday, and they told me they were expecting to get 2-3 offers over the weekend. Was that a bluff to get me to act?  I don’t know, but the seller sounded trustful, so I started to prepare an offer.

Building lot at Stelley's Cross Road

I bought and sold several homes before, but I always had my realtor help me. I contacted the delegated colleague, but I quickly got the feeling that he wasn’t very interested in helping me with a private deal.

Just a few weeks earlier I had gone to various Twitter meetings in Victoria, where I met lots of nice people – among them Scott Garman, from http://www.garmanandassociates.com. I was desperate to get some help and contacted Scott. He agreed to help me, even though he knew there was no commission for him. He even refused to take any money, and didn’t ask for anything in return for his help. He provided me with advice on the lot, and created a detailed report to help me compare the lot to other recently sold properties and homes in that area. Scott made me feel more comfortable with the deal, and on Saturday I sent an offer to the seller.

My offer wasn’t the highest, but the sellers were local people, and they liked my idea of building a log home and building a new local business. That’s why they accepted my offer over others, even though I had lots of conditions attached to the offer.

Over the next weeks I worked on removing those conditions: Get an estimate done for the bank, clear financing, make sure no old oil tanks or other obstacles are burried there, and most importantly have lots of talks with the municipality to make sure that I could build the home I was planning to build.

The seller also had some open issues, as they had not fully completed the subdivision process yet, and they had to get the title officially registered. After several weeks all issues were resolved, and I was proud owner of a piece of land in Saanich.

Lot Search Learnings

Here is a summary of things I find important when looking for a building lot:

• Get financing pre-approved before you start you lot search. Otherwise you may end up loosing your “dream lot” to other bidders. If you want to get a “good deal” on any property, you need to be well prepared and act quickly !
• Sewer service: For lots without connection to public sewer systems, make you know where and how you can put in a septic field. Costs can vary drastically depending you your lot, ranging from $5,000 to $20,000 (and higher)
• Hydro/Power: Where is the connection located? Find out what the costs will be to get power to your house. My lot had “all services at the lot line” – but I only found out later, that I still had to get a power pole on my property to connect Hydro. With connection permit costs I payed >$3,000 to get power. If you need multiple poles, a “rule of thumb” would be to calculate around $2,000 per power pole.
• Check development plans for surrounding area: This is probably the most important point. Go to the municipality responsible for your desired lot, and ask them about short and long term plans for anything going on around your desired area. I once looked at a lot with a beautiful ocean view, directly beside a park. Not cheap, but gorgeous. When I talked to the Municipality, they showed me approved plans for the neighbour property to build a 7 story condo complex! No ocean views once that goes up….
  Other important aspects to check with your municipality are design and building rules: My lot had a covenant attached with lots of design rules, and I had various discussions to make sure that I could build an EcoLog home.
• Water: Another point for non-serviced lots: You can get water nearly anywhere – but it can be really expensive. I looked at some lots which offered pre-drilled wells.  Not bad, I thought – but some research showed, that getting water out of a well can be really expensive, depending on the depth! Get expert advice on the flow capacity, water quality, and costs to get to your water !
• Get expert advice: Review your plans of buying a specific lot with some experts: Get a realtor to help you evaluating the place, and work with your lawyer in reviewing the title and other legal matters around you property !

The overall experience I had was positive. It’s fun to go “property shopping”. In the process you will see many interesting areas, and meet a lot of interesting people.

After completing this part of my new “project”, I  now had to focus on creating detailed plans for my new home!

To be continued…

Building A Log Home – Part 1, Lot Search is a post from: EcoLog-B-log

If you are planning to build your own home, or to get it built, you will soon realize that you need to cope with this unit chaos. You will have to calculate the size of your windows in inches for your builder, but your window company may ask you for metric measurements. Your architect will tell you the building hight in feet, but your municipality will have maximum hight requirements in meters. Your builder tells you to order “5 yards of concrete”, but the concrete supplier tells you prices per cubic meter.

To ease this chaos a little bit, we provide you with a nice little gadget: A website based unit converter. Check it out, it’s right here – on the right side of this page.

I tried to find such a converter for Wordpress or Joomla – but there was hardly anything available.

With my background in the IT industry I decided to have one developed. I’m not good enough in JavaScript and PHP myself, so I wrote a requirements spec, and posted it to eLance. After a few weeks my little project was completed.

If you have your own Joomla or Wordpress based website, and want to provide a Unit Converter for your visitors: Feel free to use it. I hope the little tool will soon be available through the official Wordpress and Joomla extension directories, but until then you can download it from our website here:

http://www.ecolog-homes.com/articles-and-links/41-tools

Update Januaray 2010: The unit converter is now also available through the official Joomla and Wordpress.org extension directories – just search for “unit converter”.

Unit Converter for home builders and trades people is a post from: EcoLog-B-log

Why would somebody with no background or experience in construction want to start a new company manufacturing and building log homes??? And all that during the most difficult economic times, where especially the construction industry has been hit hardest!

I was always fascinated by log homes. To me they are very natural buildings, where you can still smell and feel nature. Most of the material in a log home is wood – a very natural and renewable material. When I first told my friends in Germany that I was planning to move to Canada, many thought (in a more or less serious way) that most Canadians live in the woods, trap animals and live in log homes. Of course I was a bit disappointed after moving to British Columbia in 2000, to see that this is not totally true – but my interest and fascination with log homes remained.

In the summer of 2008 I once again visited my friend Peter Schleifenbaum in Haliburton, Ontario. He manages Haliburton Forest & Wildlife Reserve – a company with many diverse business areas. If you live in Ontario or visit Ontario, I strongly recommend that you check out the many interesting attractions available at Haliburton Forest. It’s worth more then one visit for sure…

Peter developed the EcoLog concept about 10 years ago, when he was looking for ways to create high value  products based on wood from his certified sustainable forest. Haliburton County is the most famous cottage country with prestine forests and hundreds of lakes, and many people from all over Ontario enjoy cottage life in the Haliburton region. Peter wanted to address the cottage market, and took old pioneer building methods and tweeked them to fit modern building standards and regulations. The result were EcoLog building kits, which were soon loved by many customers. Very much to Peters surprise, most of the customers wanted pretty big building instead of small and cosy cottages. The reason was that many people not only wanted to use their “cottage” for weekends or vacation, but were building it big enough to be used as their retirement residence. Over the last 10 years Peter and his company have sold more then 100 EcoLog homes of various sizes, and the charming “EcoLog look” is so popular in Haliburton county that people even start imitating it by putting “fake EcoLog siding” on their homes.

But now back to my visit to Ontario in 2008: That summer Peter told me about the background of EcoLog, and about the success as a business. I had a chance to look at several homes and was fascinated from the beatiful natural look, and from the simplicity of the building concept. We discussed if these homes could be a similar “hit” on the West Coast, as I had never seen any similar homes in BC. Peter offered me the chance to use his ideas and concepts to build a simlar business in British Columbia.

In October 2008 I started with some market research to find out what BC people think about these homes. I presented EcoLog homes at a home show, talked to many interested people, and built a website where I collected more feedback from interested potential customers. The feedback was very positive. People loved the charming look and atmosphere. That gave me enough confidence to decide that it’s time for EcoLog homes to “go West”. I started looking for suppliers, potential business partners and many different trades people. I visited Peter a few more times to learn all the details about EcoLog homes. I looked at many existing homes in Ontario, talked to builders and spent some time on construction sites to see how these homes are erected.

I’m very conscious about our environment, and I like to build and sell “eco friendly” homes. Therefore I like to “go local” wherever possible. I formed a partnership with a sawmill on Vancouver Island to provide the timber from locally grown trees. I built a network of reliable local trades people to provide the necessary materials, and to help me and my future customers build EcoLog homes. Our production process and facilities are ready now, and soon we will start putting our first “west coast” EcoLog home kit together. This kit will be used to build our future show home in Saanich, BC.

The building process for this home will be documented through a series of blog posts on this site… Stay tuned !

Bringing EcoLog Homes to the West Coast is a post from: EcoLog-B-log